Saturday, March 3, 2012

1997-2005 Buick Century/Oldsmobile Intrigue Collision Repair Issues

1997-2005 Buick Century
The fourth generation of Buick Century shares the same layout and platform with Oldsmobile Intrigue and rather hard to distinguished from Buick LeSabre, or Buick Regal. In fact Buick Century and Regal were nearly the same car with small difference only in trim and engine, the Century used less powered engine than the Regal, a 3.1L LG8 V6 engine.
The Oldsmobile Intrigue was available in 3 trims which are GX (base), GL (mid-level) and GLS (high-end), among engines that were used by Oldsmobile Intrigue were: DOHC 3.5 Shortstar engine LX5 (6 cyl engine based on GM Northstar V8), and 3.8L L36 V6 engine, 4T65-E automatic transmission also was featured to this car.
This service manual will explains steps that must be taken by General Motors’ certified technician on repairing the vehicle’ body of Buick Century and Oldsmobile Intrigue.

Contents:

Panel Identification [ 1997 Buick Century ~ 1998 Oldsmobile Intrigue ]
Radiator Support Assembly
The radiator support can be serviced as a complete assembly. The radiator support is made up of five major components: four upper and one lower.
Front Upper Rail
The front upper rail is serviced as two components: inner and outer panels. The outer panel is serviced as a sub-assembly which includes an inner reinforcement. After the outer rail has been removed, the inner rail is completely accessible and can be serviced at the factory seams.
Front Wheelhouse Assembly
The front wheelhouse service panel is serviced as a complete assembly, which includes the upper front strut mounting surface.
The upper strut mounting surface is a dimensionally critical area, and three-dimensional measuring equipment should be used to locate the front wheelhouse assembly. The front apron close-out panel is available and serviced separately.
Front Lower Rail
Sectioning procedures have been developed to simplify repair of the lower rails, providing the majority of the damage can be returned to factory specifications. This allows the damaged front section to be replaced without performing a full rail replacement. The rails are manufactured with die-marks inboard and outboard to indicate the location for the sectioning joint
Door Frame Opening
The outer door frame can be replaced as a complete service part or various segments can be sectioned. Complete service part replacement requires the removal of the roof panel.
Sectioning the outer and inner door frame reinforcement is usually much faster and more cost effective. Since the outer door frame is manufactured as a single component, service parts for sectioning must be cut from the service panel and modified as necessary.
Door Service
The doors may be serviced as complete assemblies, or the outer door panels may be serviced separately. Use conventional service procedures when repairing the doors.
Roof Panel
The roof panel is serviced as a complete assembly, including the outer panel and the inner reinforcements. The roof panel is attached by a number of welds which must be drilled to remove the outer panel and inner reinforcements for servicing
Quarter Panel
The quarter panel is serviced as a one piece service assembly which includes the lock pillar and the lower rear quarter close-out panel. Replacement of the quarter panel requires removal of the back glass. Due to the manner in which the quarter panel attaches to the door frame opening, a special sectioning procedure has been developed for improved serviceability.
Rear Outer Wheelhouse
Although full replacement of the rear outer wheelhouse can be performed, sectioning procedures have been developed for use when damage permits.
Rear Rail Assembly
The rear rails are available as a sub-assembly. Each consists of an outer panel, two inner reinforcements, and the bumper mounting bracket. The outer panel and rear bumper mounting brackets are also available separately to facilitate sectioning. Additionally, there is a crossbar that connects the two rear rails for added strength and rigidity.
Rear Floor
The damaged floor is cut along the rearward edge of the rear crossbar, and the service part is cut so that the new floor section extends to the front edge of the rear crossbar. This allows the two sections to overlap where the crossbar is attached.
Rear End Panel Assembly
The rear end panel is supplied as a complete assembly. Quarter panel extensions attach to the outside corners of the rear end panel. Service for this panel is performed at factory seams.
Body Dimensions [ Underbody ~ Front ~ Engine Compartment ~ Buick Century Door Frame Opening ~ Oldsmobile Intrigue Door Frame Opening ~ Rear ~ Form and Pierce ~ Buick Century/Oldsmobile Intrigue Hole Identification Chart ]
Download
Read More..

1988 Buick Electra Park Avenue Electrical Diagrams ECM Wiring Diagrams Late Production (After 10-87)

1988 Buick Electra Park Avenue Electrical Diagrams
1988 Buick Electra Park Avenue Electrical Diagrams ECM Wiring Diagrams Late Production (After 10-87) Park Avenue is a limited trim level of Buick Electra, the Buick Electra Park Avenue is the most luxuriously equipped and fully featured Electra and introduced in 1985 with a redesigned front wheel drive instead of rear wheel drive driven vehicle.
This wiring diagram contains information on ECM module wiring schematics of 1988 Buick Electra Park Avenue, with V6 3.8L engine mounted on it. Download
Read More..

2005 Buell Firebolt Models Service Manual

2005 Buell Firebolt Models
2005 Buell Firebolt Models Service Manual

This service manual consists information should be known by Buell technician on performing maintenance, service, repair, troubleshooting of the Buell Firebolt XB9R and XB12R model year 2005.

Contents:

Section 1: Maintenance
Section 2: Chassis
Section 3: Engine
Section 4: Fuel System
Section 5: Starter
Section 6: Drive/Transmission
Section 7: Electrical
Appendices
Download
Read More..

BMW Transmission Specification

BMW Transmission Specification
BMW Transmission Specification This document I assume, is a part of the Bimmer Specification/Manual but I had no luck to find other correspond pdf files. It’s about a BMW Transmission Specification, I thought it might be useful for someone that is currently looking for BMW Tranny Specs.

Inside You can find informations about:

Valve Body Components
Pressure Regulator Solenoids (EDS)
Magnetic Valve Shift Solenoids (MV)
Input (Turbine) and Output Speed Sensors
Transmission Oil Temperature Sensor
Transmission Powerflow
A5S 310/270R Valve Body Components
A4S 310/270R Power Flow Schematic
A5S 360R (GM5) Valve Body Components
A5S 360R (GM5) Powerflow Schematics
A5S 310Z Valve Body Components
A5S 310Z Valve Body Resistance Nominal Values
A5S 440Z Valve Body Components
A5S 440Z Power Flow Schematic
A5S 560Z Valve Body Components
A5S 560Z Power Flow Schematic


Download
Read More..

L-Jetronic Fuel Injection Systems for BMW E12

L-Jetronic Fuel Injection Systems for BMW E12
L-Jetronic Fuel Injection Systems for BMW E12 This pdf material will describe the L-Jetronic system fitted on E12’s and also cover Jetronic’s troubleshooting and performance tips.
Exemplary work from firstfives.org, although it’s a very brief pdf file, no wonder because in the bibliography section and suggested reading they also have some great books such as: Technical Instruction L-Jetronic - # VDT-U 33 En - Robert Bosch GmbH; Owners Workshop Manual BMW 528i & 530i - Haynes Publishing Group ISBN 0 85696 632 0; Bosch Fuel Injection and Engine Management - Charles O. Probst, SAE - Robert Bently Publishers #GFIB; ISBN 0-8376-0300-5; BMW Fuel Injection - Jim Blanton & Jim Rowe - Metric Mechanic Kansas City, MO 816-842-7232.

Contents:

Basic Engine Combustion Process
Combustion Requirements
Fuel Delivery Implementations
Electronic Fuel Injection System Components
L-Jetronic System
Troubleshooting
Conversion to Lambda Control
Performance Download
Read More..

2004 BMW R 1200 GS Electric Schematic

2004 BMW R 1200 GS Electric Schematic
2004 BMW R 1200 GS Electric Schematic The BMW R 1200 GS motorcycle is equipped with ABS, Anti-theft alarm, Hand guards, Heated handgrips, Saddle bag mounts, Saddlebags, with an Anti Locking Brake Systems on its wheel. With an air/oil-cooled flat twin (’Boxer’) 4-stroke, one camshaft and four valves per cylinder engine, this 1 170 cc engine boasts around 100 HP at 7000 rpm.

This is an electrical schematic (possibly incomplete) of BMW R1200GS, 1.17L model year 2004. Although it is not complete, I believe the Bimmer Bike owners should have this material.

Contents:

* BMW R 1200 GS Terminal Designations and Electrical Legends
* R 1200GS Electrical Component Locations Diagram I
* R 1200GS Electrical Component Locations Diagram II
* Lighting/Turn Signals/Horn (ZFE)
* Power Distribution and Grounds
* Starter/Alternator
* BMS K - Engine Management Schematics
* Integral ABS / I Cluster
* Socket/HEated Handgrips/ Diagnosis Plug/ Optional Accessory Socket
* Anti Theft Alarm System DWA VI


Download
Read More..

BMW Motorrad Navigator III Owner’s Manual

BMW Motorrad Navigator III
BMW Motorrad Navigator III Owner’s Manual The BMW Motorrad Navigator III is fitted with state-of-the-art technology such as Bluetooth, satellite-based GPS navigation, many sensible additional functions such as communication aids and deliberately simple user guidance. This means you can find your way to any destination reliably and precisely - following your own personal route to increased riding pleasure.

Contents:

Preface
Find It and Go
Where To
My Locations
Using the Map
Creating and Editing Routes
Using the Track Logs
Using Bluetooth Wireless Technology Features
Traffic Information
Customizing the Navigator III
Appendix
Navigator III Troubleshooting

Download
Read More..

2003 Mini Cooper & Mini Cooper S Owner’s Manual

2003 Mini Cooper
2003 Mini Cooper & Mini Cooper S Owner’s Manual

This owner’s manual informs you everything you should know regarding BMW MINI Cooper and MINI Cooper S features and control, security systems, maintenance and engine specification. Covered herein is MINI Cooper and MINI Cooper S Model Year 2003 with 1.6L Tritec I4 and 1.6L Tritec I4 Turbocharged version attached inside its compartment.

Contents:

Notes [ About this Owner's Manual ~ Symbols used ~ Your individual vehicle ~ Editorial notice ~ For your own safety ~ Symbol on vehicle parts ~ Service and warranty ~ Reporting safety defects ]
At a glance [ Cockpit ~ Display elements ~ Display elements with navigation ~ system ~ Indicator and warning lamps ~ Multifunction steering wheel ]
Opening and closing: [ Keys ~ Central locking system ~ Opening and closing – from outside ~ Opening and closing – from inside ~ Tailgate ~ Electric power windows ~ Sliding/tilt sunroof ~ Roller sun blind ~ Alarm system ]
Adjustments: [ Safe seating position ~ Seat adjustment ~ Entry to the rear ~ Heated seats ~ Head restraints ~ Safety belts ~ Steering wheel ~ Mirrors ~ Airbags ~ Transporting children safely ~ Vehicle Memory ]
Driving: [ Ignition lock ~ Starting the engine ~ Switching off the engine ~ Parking brake ~ Manual transmission ~ Continuously Variable automatic Transmission (CVT) ~ Parking lamps/Low beams ~ Turn signal indicator/Headlamp flasher ~ Instrument lighting ~ Fog lamps ~ Interior lamps ~ Light-emitting diodes ~ Washer/wiper system ~ Cruise control ]
Everything under control: [ Odometer ~ Tachometer ~ Fuel gauge ~ Coolant temperature gauge ~ Service interval display ~ Clock ~ Computer ]
Technology for safety and driving convenience: [ Automatic Stability Control plus Traction (ASC+T) ~ Dynamic Stability Control (DSC) ~ Flat Tire Monitor ~ Park Distance Control (PDC) ]
Controlling the climate for pleasant driving: [ Air conditioning system ~ Automatic climate control ]
Interior conveniences: [ Glove compartment ~ Ashtray/Beverage holder ~ Cigarette lighter/12 V power supply ]
Loading and transporting cargo: [ Cargo area cover ~ Foldable rear backrest ~ Loading cargo ~ Roof-mounted luggage rack ]
Special operating instructions: [ Break-in procedures ~ General driving notes ~ Refueling ~ Fuel specifications ~ Antilock Brake System (ABS) ~ Brake system ]
Wheels and tires: [ Tire inflation pressure ~ Tire condition ~ Tire replacement ~ Wheel and tire combinations ~ Winter tires ~ Snow chains ]
In the engine compartment: [ Bonnet ~ Engine compartment – MINI COOPER ~ Engine compartment – MINI COOPER S ~ Washer fluid ~ Engine oil ~ Coolant ~ Brake fluid ]
Maintenance and care: [ MINI Maintenance System ~ Caring for your vehicle ~ Vehicle immobilization ]
Laws and regulations: [ OBD socket ~ Technical modifications ~ California Proposition 65 warning ]
Replacement procedures: [ On-board tool kit ~ Windshield wiper blades ~ Lamps and bulbs ~ Repairing a flat tire ~ Changing tires – ~ MINI with space-saver spare tire ~ Flat tire – Run Flat tires ~ MINI Mobility System ~ Battery ~ Fuses ]
Giving and receiving assistance: [ Warning triangle ~ First-aid kit ~ Jump-starting ~ Towing ]
Technical data [ Engine data ~ Dimensions ~ Weights ~ Capacities ] Download
Read More..

Audi S8 Quick Reference Guide

Audi S8 Quick Reference Guide This reference is not by any mean to replace the official Audi S8 owners manual, this reference only introduces you to the main features and controls of the Audi S8 sedan.

Topic Coverage in this reference guide:

Locking and Unlocking the Vehicle
Adjusting the Front Seats
SunRoof
Safety
Instruments and Warning/Indicator Lamps
Filling the tank
Overview of Control and Equipment

Download
Read More..

2001 BMW 325Ci/330Ci Owner’s Manual

2001 BMW 325Ci/330Ci User Manual Read this Owner’s Manual to get summarized information, before you start out in your new BMW. It contains important data and instructions intended to assist you in gaining maximum use and satisfaction from the unique range of technical features on your BMW.
This manual also contains information on maintenance and care, designed to ensure your safety and the proper operation of your vehicle, and to maintain your vehicle’s value. This Owner’s Manual should be considered a permanent part of this vehicle.
It should stay with the vehicle when sold to provide the next owner with important operating, safety and maintenance information. BMW 325Ci/330Ci Owners Manual’ table of contents: Overview, Controls and features, Operation, care and maintenance, Owner service procedures, Technical data, Advanced technology, Index. Download
Read More..

2000 BMW R 1150 GS Electrical Circuit Diagram

2000 BMW R 1150 GS Electrical Circuit Diagram BMW R 1150 GS is equipped with Digital Motor Electronic (MOTRONIC) engine management including a high power ignition system. This Electrical Circuit Diagram provides comprehensive informations on electrical diagram, components, connections on yout BMW R 1150 GS Model bike/motorcycle.
It covers left/right/front wiring harness schematic, relays, fuses, lighting schematic with stop light, relays with fuses schematic, motronic with output/input schematic, ABS schematic, Driver Informatio Display (FID) Schematic, Heating and Anti-Theft System. Download
Read More..

2005 Chevrolet Uplander Owner Manual

2005 Chevrolet Uplander User Manual Chevrolet Uplander is one of the first crossover between minivan and SUV, it replaced Chevy Venture and Chevrolet Astro and built on U-body platform. Chevy Uplander was first introduced in 2005, from the first production till now has been using 3.5 L LX9 V6, 3.9 L LZ9 V6, 3.9 L LGD V6 engines on its base model.
This owners manual will give information user/owner/driver should know before their first engine starting.
2005 chevrolet uplander

QuickPost

Contents:

Seats and Restraint Systems
Features and Controls
Instrument Panel
Driving Your Vehicle
Service and Appearance Care
Maintenance Schedule
Index
Download
Read More..

2000 Cadillac Escalade Owner’s Manual

2000 Cadillac Escalade Owner’s Manual The Cadillac Escalade is a full-size luxury sport utility vehicle, was introduced for the 1999 model year in response to Ford’s Lincoln Navigator. This SUV was originally based on Yukon Denaly’s GMC SUV, until it was redesigned in preparing the 2002 MY.
The first generation of Cadillac Escalade used the 5.7 L Vortec 5700 V8 engine and featured Autotrac selectable 4×4 drivetrain.
This manual is for the owners of Cadillac Escalade’s first generation SUV, through reading comprehensive owners manual owners will get acquainted quickly to the features and controls of the 2000 Cadillac Escalade. Download
Read More..

2004 BMW X3 2.5i X3 3.0i Manual

2004 BMW X3 2.5i, X3 3.0i Owners Manual BMW X3 comes in two flavor the 2.5i, which refers to the vehicle’s 2.5L inline 6-cylinder engine (184 horsepower and 175 pound-feet of torque), and the 3.0i (225 hp and 214 lb-ft from a larger inline six) which are based on BMW E83 platforms. The X3 SUV is less expensive than the older brother X5 which is a SAV (Sport Activity Vehicle). Optionally equipped with the 5 speed Automatic Transmission called Steptronic that offers drivers 3 choice of modes: normal, sport and manual shift.
For comfortable and safe riding, BMW provides arrays of features, controls and accesories inside the X series. This Manual will help you get acquainted with it to obtain the safest and most comfortable riding experience.

Following are chapters inside the BMW X3 series owners manual:

Using this Owner’s Manual
Notes
At a glance
Cockpit
Controls
Opening and closing
Adjustments
Transporting children safely
Driving
Everything under control
Technology for comfort, convenience and safety
Lamps
A congenial climate
Practical interior accessories
Driving tips
Things to remember when driving
Mobility
Refueling
Wheels and tires
Under the engine hood
Maintenance
Laws and regulations
Replacing components
Giving and receiving assistance
Reference
Technical data
Everything from A to Z
Download
Read More..

Daewoo Nubira/Lacetti LIGHTING SYSTEMS Service Manual

Daewoo Nubira/Lacetti LIGHTING SYSTEMS Service Manual
Contents:
SPECIFICATIONS [ Bulb Usage Chart ~ Fastener Tightening Specifications ]
SCHEMATIC AND ROUTING DIAGRAMS [ Backup Lamps Circuit ~ Instruments Circuit (W/O Dimmer Control : General Only) ~ Instruments Circuit (W/ Dimmer Control) ~ Front And Rear Fog Lamps Circuit ~ Headlamps-On Reminder Chime Circuit ~ Headlamps and Headlamp Leveling Circuit ~ Daytime Running Lamps Circuit ~ Parking, Tail and License Lamps Circuit ~ Stoplamps Circuit ~ Turn and Hazard Lamps Circuit ~ Interior Courtesy and Luggage Compartment Lamp Circuit ]
DIAGNOSIS [ Headlamps-On Reminder Chime ~ Headlamps ~ Headlamp Leveling ~ Daytime Running Lamps ~ Parking Lamps and Taillamps ~ Interior Courtesy and Luggage Compartment Lamps ~ Fog Lamps ]
MAINTENANCE AND REPAIR [ ON-VEHICLE SERVICE ~ Headlamps/Front Turn Signal Lamps ~ Daytime Running Lamp Module ~ Parking Lamps ~ Side Turn Signal Lamps ~ Front Fog Lamps ~ Notchback Rear Combination Lamps ~ Hatchback Rear Combination Lamps ~ Hatchback Extension Lamps ~ Notchback Center High-Mounted Stoplamp ~ Hatchback Center High-Mounted Stoplamp ~ License Plate Lamps ~ Door Jamb Switch ~ Center Room Lamp ~ Map Lamp ~ Luggage Compartment Lamp ~ Ashtray and Cigar Lighter Lamp]
GENERAL DESCRIPTION AND SYSTEM OPERATION [ Headlamps-On Reminder Chime ~ Headlamps ~ Daytime Running Lamps ~ Parking and Turn Signal Lamps ~ Fog Lamps ~ Rear Combination Lamps ~ License Plate Lamp ~ Interior Courtesy Lamp ~ Luggage Compartment Lamp ~ Backup Lamps ] Download
Read More..

Friday, March 2, 2012

2006 Chevrolet HHR Owner Manual

2006 Chevrolet HHR User Manual

Chevy Heritage High Roof (Chevrolet HHR) use the same platform as Pontiac G5, Chevy Cobalt and Saturn Ion. Using Ecotec L61 I4 or Ecotec LE5 I4 combined with automatic transmission or manual transmission (optionaly), this retro looking car will leave all true retro vehicle behind its tail.
This manual was prepared by Chevrolet Automobile, one of General Motors division to provide suffice informations on preparing, driving and maintaining the vehicle.
chevrolet HHR

QuickPostContents:

Seats and Restraint Systems
Features and Controls
Instrument Panel
Driving Your Vehicle
Service and Appearance Care
Maintenance Schedule
Download
Read More..

1997-2005 Buick Park Avenue Collision Repair Issues

1997-2005 Buick Park Avenue Collision Repair Issues C body (similar to G body used by Buick Riviera) was used by this full size car as its main platform. This car was powered by 3800 Buick V6 engine, and available in automatic transmisison (4-speed 4T65-E). In 2005 GM discontinued the Park Avenue production and was replaced by Buick Lucerne.
This repair manual covers various information regarding collision repair issues (caution this is not an engine/wiring service manual!).

Contents:

Panel Identification
Radiator Support Assembly
Upper Rail Assembly
Front Wheelhouse Assembly
Lower Rail Assembly
Door Service
Door Frame Opening
Roof Panel
Quarter Panel
Rear Rail Assembly
Rear Floor
Rear End Panel
Body Dimensions
Download
Read More..

2003 Buell Firebolt XB9R Model Official Factory Manual (Part No. 99493-03Y)

2003 Buell Firebolt XB9R Model Official Factory Manual (Part No. 99493-03Y)

A Service/Repair Manual for Buell Firebolt XB9R (and I assume also for Firebolt XB9), Buell motorbike is known as its slogan ‘an American Motorcycle’. Buell motorcycle company was found by Erik Buell and has been renowned on its fast and stylish motorcycle, during its production, Buell launched various motorbike such as Ulysses, Firebolt, Lightning, Blast and many other.

Contents:

Maintenance [ General ~ Fluid Requirements ~ Care of Molded in Color Body Panel ~ Battery Maintenance ~ Engine Lubrication System ~ Brake System Maintenance ~ Tires and Wheels ~ Clutch ~ Drive Belt System ~ Primary Chain ~ Suspension Damping Adjustment ~ Front Fork Oil Change ~ Steering and Head Bearings ~ Spark Plugs ~ Air Cleaner Filter ~ Throttle Cable and Idle Speed Adjustment ~ Ignition Timing ~ Headlights ~ Throttle Position Sensors (TPS) ~ Storage ~ Troubleshooting ]
Chassis [ Specifications ~ Tire Specs ~ Vehicle Identification Number ~ Wheels ~ Front Wheel ~ Rear Wheel ~ Checking Cast Rim Runout ~ Tires ~ Brake Pedal ~ Front Brake Master Cylinder ~ Front Brake Line ~ Front Brake Caliper ~ Rear Brake Master Cylinder ~ Rear Brake Line ~ Rear Brake Caliper ~ Front Fork ~ Fork Clamps Upper and Lower ~ Steering Head Bearings ~ Swingarm and Brace ~ Front and Rear Isolator ~ Frame ~ Rear Shock Absorber ~ Throttle Control ~ Clutch Hand Lever ~ Headlight Support Bracket ~ Handlebars ~ Exhaust System ~ Footpeg Heel Guard and Mount ~ Sprocket Cover ~ Fenders ~ Belt Guards ~ Chin Fairing ~ Intake Cover Assy ~ Air Scoops ~ Tail Frame and Body Work ~ Front Fairing Winshield and Mirrors ~ Seat ~ Passenger Seat Lock ~ Slidestand ]
Engine [ Specifications ~ ENgine ~ Engine Rotation for Service ~ Stripping Motorcycle for Engine Service ~ Engine Installation ~ Cylinder Head ~ Cylinder and Piston ~ Lubrication System ~ Ol Hose Routing and Oil Reservoir ~ Oil Pressure Indicator Switch ~ Crankcase Breathing System ~ Oiling System ~ Oil Filter Mount ~ Hydraulic Lifters ~ GEarcase Cover and Cam Gears ~ Crancase ]
Fuel System [ Specifications ~ Dynamic Digital Fuel Injection ~ Diagnostic Introduction ~ Checking for Trouble Codes ~ Check Engine Lamp Diagnostics ~ Breakout Box ~ Wiggle Test ~ Initial Diagnostic Check ~ Check Engine Lamp Not Illuminated at Key ON ~ Engine Cranks But Will not Start ~ No ECM Power ~ Fuel Pressure Test ~ Idle Speed Control ~ Misfire ~ Trouble Code 11 ~ Trouble Code 13 ~ ~ Trouble Code 14 ~ Trouble Code 15 ~ Trouble Code 16 ~ Trouble Code 23 and 32 ~ Trouble Code 24 and 25 ~ Trouble Code 33 ~ Trouble Code 36 ~ Trouble Code 44 ~ Trouble Codes 52, 53, 54, and 55 ~ Trouble Code 56 ~ Electronic Control Module ~ Cam Position Sensor and Rotor ~ Ignition Coil ~ Oxygen Sensor ~ Engine Temperatur Sensor ~ Bank Angle Sensor ~ Intake Air Temperature Sensor ~ Cooling Fan ~ Fuel Pump ~ Fuel Tank Vent Valve ~ Fuel Cap Retaining Ring ~ Throttle Body and Intake Manifold ~ Intake Leak Test ~ Airbox ~ Evaporatice Emissions Control California Models ]
Electric Starter [ Specs ~ Electric Starter System ~ Starting System Diagnosis ~ Starter Activation Circuits ~ Diagnostics Troubleshooting ~ Starter System Testing ~ Starter ~ Starter Solenoid ]
Drive/Transmission [ Specs ~ Primary Chain ~ Clutch Release Mechanism ~ Primary Drive/Clutch ~ Transmission ~ Case Disassembly for Transmission Removal ~ Transmission Disassembly ~ Transmission Assembly ~ Main Drive Gear ~ Transmission Right Case Bearings ~ Transmission Left Case Bearings ~ Transmission Installation ~ Shifter Shaft Installation ~ Transmission Sprocket ]
Electrical [ Specs ~ Ignition System ~ Ignition Headlight Key Switch ~ Spark Plug Cables ~ Starter Interlock ~ Charging System ~ Alternator ~ Voltage Regulator ~ Battery Cables ~ Battery ~ Headlight ~ Tail Lamp ~ Turn Signals ~ Turn Signal Flasher ~ Handlebar Switches ~ Speedometer Sensor ~ Instrument Module ~ Speedometer Performance Check ~ Tachometer Performance Check ~ Horn ~ Neutral Indicator Switch ~ Main Fuse and Fuses ~ Main Wire Harness ~ Sprocket Cover Wiring ]
Appendices [ Tools ~ Amp Multilock Electrical Connectors ~ Deutsch Electrical Connectors ~ Packard Electrical Connectors ~ Electrical Connectores ~ Index to Wiring Diagrams ~ Metric Conversions ~ Fasteners Torque Values ~ Hose and Wire Routing ]
Index Download
Read More..

1995 Chevrolet Lumina Owners Manual

1995 Chevrolet Lumina Owners Manual

When it was introduced in 1989, Chevy Lumina was available in sedan and minivan until later in 1997 Lumina APV was replaced by Chevrolet Venture to avoid confusion. Lumina is intended to replace Chevy Celebrity and Chevy Monte Carlo. Like any other vehicle thrown on market, Chevy Lumina also has one ‘high performance’ variant, which is Chevrolet Lumina Z34 with 3.4 L DOHC LQ1 V6 engine fitted on it engine compartment.
Although the second generation of Chevrolet Lumina is offered in three different engines (which is 3.1L L82 V6/code M, 3.4L LQ1 V6/code X and 3.8L L36 V6) this manual does not cover the last engine written above, and also covers maintenance schedules, features and controls of Chevy Lumina 1995.

Contents:

Seats and Restraint Systems
This section tells you how to use your seats and safety belts properly. It also explains the air bag system.
Features and Controls
This section explains how to start and operate your 1995 Chevrolet Lumina.
Comfort Controls and Audio Systems
This section tells you how to adjust the ventilation and comfort controls and how to operate your sound system.
Your Driving and the Road
Here you’ll find helpful information and tips about the road and how to drive under different conditions.
Problems on the Road
This section tells you what to do if you have a problem while driving, such as flat tire or engine overheating, etc.
Service and Appearance Care
Here the manual tells you how to keep your Chevrolet Lumina running properly and looking good.
Maintenance schedule
This section tells you when to perform vehicle maintenance and what fluids and lubricants to use.
Customer Assistance Information
This section tells you how to contact Chevrolet for assistance and how to get service publications. It also gives you information on “Reporting Safety Defects”.
Index
Here’s an alphabetical listing of almost every subject in this manual. You can use it to quickly find something you want to read. Download
Read More..

2006 BMW Z4 M Roadster, Z4 M Coupe Owners Manual

2006 BMW Z4 M Roadster, Z4 M Coupe Owners Manual Before starting off in your new BMW Z4 M Roadster/Z4 M Coupe, please take the time to read this Supplementary Owner’s Manual and familiarize yourself with the information that BMW AG have compiled for you. The manual contains important data and instructions intended to assist you in obtaining maximum satisfaction from your BMW Z4 M Roadster’s/Z4 M Coupe’s unique array of advanced technical features.

Inside this owner manual:

Using this Owner’s Manual
Notes
At a glance
Cockpit
Controls
Everything under control
Technology for driving comfort and safety
Driving tips
Special operating instructions
Mobility
Refueling
Wheels and tires
Under the hood
Replacing components
Reference
Technical data
Everything from A to Z
Download
Read More..

Daewoo Nubira/Lacetti Interior trim service manual

Daewoo Nubira/Lacetti Interior trim service manual This PDF File contents:
SPECIFICATIONS [ Fastener Tightening Specifications ]
SPECIAL TOOLS [ Special Tools Table]
MAINTENANCE AND REPAIR [ ON-VEHICLE SERVICE ~ Front Door Trim Panel ~ Rear Door Trim Panel ~ A-pillar Trim Panel ~ Upper B-pillar Trim Panel ~ Lower B-pillar Trim Panel ~ C-pillar Trim Panel ~ Deck Lid Sill Plate Cover ~ Front Rocker Trim Panel ~ Rear Rocker Trim Panel ~ Front Wheelhouse Trim ~ Rear Wheelhouse Trim ~ Floor Console ~ Floor Carpet ~ Luggage Compartment Rear Low Cover ~ Luggage Compartment Wheelhouse Trim Panel ~ Driver's Side Knee Bolster ~ Hatchback Door Lower Garnish Molding ~ Hatchback Door Upper Garnish Molding ~ Luggage Compartment Wheelhouse Trim Panel (HATCHBACK) ~ Luggage Compartment Rear Trim Panel]
GENERAL DESCRIPTION AND SYSTEM OPERATION [ Interior Trim Panels ~ Pressure Relief Vent ~ Floor Console ~ Floor Carpet ~ Rear Compartment Security Cover (HATCHBACK) ]
Download
Read More..

Towing and Road Service Procedures for the 2002 BMW Mini Cooper and Mini Cooper S

Towing and Road Service Procedures for the 2002 BMW Mini Cooper and Mini Cooper S This 6 pages pdf reference consists of useful information on Towing, Jacking, Tire Change and Jump Starting of BMW Mini Cooper and BMW Mini Cooper S model year 2002.
Download
Read More..

2000 BMW 323i, 328i Owner’s Manual

2000 BMW 323i, 328i User Manual BMW 323i, 328i User Manual.pdf contains important data and instructions intended to assist you in gaining maximum use and satisfaction from the unique range of technical features on your BMW. This manual also contains information on care and maintenance designed to enhance operating safety and contribute to maintaining the value of your BMW throughout an extended service life.

Inside this owners manual:

Overview
Controls and features
Operation, care and maintenance
Owner Service Procedures
Advanced Technology
Technical data
Index Download
Read More..

Audi - The 2.7-litre V6 Biturbo Design and Function Self-study Programme 198

Audi - The 2.7-litre V6 Biturbo Design and Function Self-study Programme 198
Another good source to learn about the milestone engine development by Audi, the Audi self study Programme (pdf file). This is not an Audi Service/Workshop Manual and not in anyway intended to replace the Audi Service Manual. However, it contains lots informations on V6 biturbo 2.7l .. a superb engine that is developed by Audi engineers.

Here’s what this reference covers:

Engine [Technical data, crankshaft, cylinder head, camshaft timing, cooling circuit, engine lubrication, overview of components, air ducting, charging, exhaust system, pneumatically controlled systems, charge pressure control, air divert control in overrun, ACF system, crankcase breather]
Motronic ME 7.1 [Subfunctions, system overview]
Subsystems of the Motronic [Torque-oriented engine management, torqueoriented functional structure, Electronic throttle, exhaust gas temperature control]
Sensors [Additional sensors of the Motronic]
Auxiliary signals/interfaces
Functional diagram
Self-diagnosis [Vehicle diagnosis, test and information system VAS 5051, test box V.A.G 1598/31]
Transmission [Self-adjusting clutch, gearbox] Download
Read More..

2006 BMW 525i, 530i, 545i, 525xi, 530xi Owner’s Manual

2006 BMW 525i, 530i, 545i, 525xi, 530xi Owner’s Manual This user manual contains important data and instructions intended to assist you in gaining maximum use and satisfaction from your BMW’s unique range of technical features.2006 BMW 525i, 530i, 545i, 525xi, 530xi owners should take time to read this owners manual and familiarize themself with the informations contains herein.

Short Table of Contents:

Using this Owner’s Manual
At a glance
Controls
Driving Tips
Navigation
Entertainment
Communications
Mobility
Reference Download User Manual
Read More..

2005 Chevrolet Cobalt Owner Manual

2005 Chevrolet Cobalt User Manual Chevrolet Cobalt was first introduced in 2004 and is intended to replace Chevy Cavalier and Chevy Prizm. This compact car is available in coupe and sedan, whether in high performance and super sport variant. Combination between either 2.0 L Turbo LNF I4, 2.0 L S/C LSJ I4, 2.2 L L61 I4, 2.2 L LAP I4, 2.4 L LE5 I4 engine and transmissions 4-speed 4T45 automatic, 5-speed F35 (MU3) manual and 5-speed Getrag F23 manual and MacPherson struts independent suspension is a value added offered by Chevrolet attached in this car. This manual describes step by step information on safety, maintenance, driving, features and control available in this car, although it contains small parts of maintenance schedule and do it yourself, this is not a service manual. Download
Read More..

Thursday, March 1, 2012

2006 Chrysler 300 300C Chrysler 300 Touring Dodge Magnum and Dodge Charger SRT-8 Service Manual

2006 Chrysler 300 300C Chrysler 300 Touring Dodge Magnum and Dodge Charger SRT-8 Service Manual
2006 Chrysler 300, 300C, Chrysler 300 Touring, Dodge Magnum and Dodge Charger, SRT-8 Service Manual

Service/repair manual and wiring diagram of various General Motors’ Chryslers and Dodge, covers the following vehicles: Chrysler 300, 300C, Chrysler 300 Touring, Dodge Magnum, Dodge Charger, and Dodge SRT-8. All vehicles written earlier use the same vehicle platform, an LX Platform.

Following engine also are covered in this repair manual:

3.0L V-6 cyl. Turbo Diesel Sales Code (EXL)
3.5L V-6 cyl. High Output 24 Valve MPI Gasoline Sales Code (EGG)
5.7L V-8 cyl. HEMI Multiple Displacement Gasoline Sales Code (EZB)
3.0L V6 CYL 24 Valve Turbo Diesel Sales Code (EXL) (Hatchback)
2.7L V6 Cyl. 24V DOHC Gasoline (MPI) Sales Code (EER)
2.7L V6 CYL 24 ValveDOHC Gasoline MPI Sales Code (EER) (Hatchback)
3.5l V6 CYL 24 Valve High Output Gasoline, Sales Code (EZB) (Hatchback)
6.1L V8 CYL SRT HEMI Gasoline SMPI, Sales Code (ESF)
5.7L V8 CYL HEMI Multiple Displacement Gasoline Sales Code ( EZB) (Hatchback)
6.1L V8 CYL SRT HEMI Gasoline SMPI, Sales Code (ESF) (Hatchback)

Transmissions are:

4 Speed Automatic, Sales Code (DG6)
4 Speed Automatic VLP, Sales Code (DGV)
5 Speed Automatic, Sales Code (DGJ)

Contents:

Introduction
Lubrication & Maintenance
Suspension
Differential & Driveline
Vehicle Quick Reference
Brakes
Cooling
Audio/Video
Chime/Buzzer
Clock
Electronic Control Modules
Engine Systems
Heated Systems
Horn
Ignition Control
Instrument Cluster
Lamps
Message Systems
Power Systems
Restraints
Speed Control
Vehicle Theft Security
Wipers/Washers
Navigation/Telecommunication
Wiring
Engine
Exhaust System
Frame & Bumpers
Fuel System
Steering
Automatic Transmission
Tires/Wheels
Body
Heating & Air Conditioning
Emissions Control Download
Read More..

D7 BMW Marine Engines

D7 BMW Marine Engines

The BMW D7 is a single-cylinder, four-stroke, direct-injection diesel engine. The engine is equipped with a raw-water cooling system, fed by an impeller type pump driven by the crankshaft. Electrical starting and charging systems are standard as is an automatic air bleeder device in the fuel system.
This manual was written on your behalf in an effort to help you enjoy your new BMW Marine Engine to the maximum. No marine engine, be it the best in the world, will perform at it’s best during a long life, without proper care and maintenance.

D7 BMW Marine Engines.pdf Table of contents:

ENGINE DESCRIPTION
INSTRUMENTS AND CONTROLS
STARTING AND OPERATING
SERVICE & MAINTENANCE
FUEL SYSTEM
LUBRICATION SYSTEM
COOLING SYSTEM
VALVE SYSTEM
ELECTRICAL SYSTEM
WINTER LAY UP AND RECOMISSION
Download
Read More..